Volkswagen Jetta 2005 Manual do Utilizador descarregar pdf

FLUID CAPACITY CHART

E 2005 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are

reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the

publisher.

1 of 6

MY /

VEHICLE

ENGINE OIL MANUAL TRANS. AUTOMATIC

TRANS.

DIFFERENTIAL

AUTOMATIC TRANS.

COOLING SYSTEM



POWER

STEERING

WINDSHIELD

WASHER

A/C REFRIGERANT

R-134a

A/C REFRIGERANT OIL

See VESIS for oils

Jetta/Golf

GTI

Jetta

Wagon

2005

new

Jetta

w/filter change

1.8T(AWP/

AWPIA)

4.5L (4.8 qt)

1.9 TDI PD

(BEW)

4.5L (4.8 qt)

2.0

(BEV,BBW)

4.2L (4.4 qt)

2.5

(BGP/BGQ)

Approx

6.0L(6.3 qt)

2.8 (BDF)

5.5L (5.8 qt)

02M

2.3L (2.4 qt)

02J

2.0L (2.1 qt)

Rear Final Drive

02D

1.0L (1.1 qt)

01M

New fill: 5.3L

(5.6 qt)

Refill: approx.

3.0L (3.2 qt)

09A

New fill: 7.0 L

(7.4 qt)

09G

New fill: 7.0L

(7.4 qt)

See VESIS

for filling after

repairs

with trans 02M

New fill: 0.75L (0.80 qt)

See VESIS for filling

after repairs

with trans 09A/09G

Capacity included with

Automatic Transmission

See VESIS for filling

after repairs

1.8 T (AWP/AW-

PIA)

5.0L (5.3 qt)

1.9 (BEW)

6.0L (6.3 qt)

2.0 (BEV,BBW)

5.0L (5.3 qt)

2.5(BGP/BGQ)

9.0L(9.5 qt)

2.8 (BDF)

9.0L (9.5 qt)

0.7-0.9L

(0.74-0.95 qt)

use hydraulic

oil G 002 012

Do not use

ATF

3.0 L (3.2 qt)

Use concentrated

ZVW 177

901/903/904/906

Windshield

washer container

also serves rear

washer on

wagons

new Jetta

5.0L(5.2qt)

w/headlight

washer

750+50 g

(26+1.8 oz)

new Jetta

525+

25 g

(18.5 + 0.9 oz)

Golf/Jetta fr 10/98 w/

Sandon compressor

135+15 cc

(4.6+

0.5 fl. oz)

Golf from 11/98 w/

Zexel compressor

115 + 20 cc

(3.9 + 0.7 oz)

See VESIS for PAG

oils

new Jetta

110 +

10 cc

(3.7 + 0.3 oz)

PAG oil

G 052 200 A2

ENGINE OIL: Approx qty! Use petroleum or synthetic(synthetic specifically for new Jetta)oils meeting VW oil quality standard: VW502 00(a must for 1.8T),

or VW500 00 or VW 501 01, ACEA A2 or A3(A3 for 1.8T), (TDI–PD) Use ONLY VW 505 01, ACEA B3/B4. Use viscosity 5W40 or if not avail 5W30.Don’t overfill!

Overfilling can cause misfire DTC’s to be stored in Engine Control Module (ECM) -J220-. To prevent overfil, add approx.0.5L less than cap, start engine,run til

eng op temperature is approx. 60_C (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See RM for details. Turbo engines only:

After changing oil and filter, start and run engine at idle til oil pressure light goes out. DON’T rev eng, this could cause damage/ failure of turbocharger.

MANUAL TRANS: 02J:Use mineral oil, SAE 75W90, Part No. G 052 726 A2, 02M: Use synthetic oil SAE 75W90, Part No. G 052 171 A2.

AUTOMATIC TRANS: Use VW ATF, Part No. G 052 162 A2(1 liter container) for 01M trans, G 052 990 A2(1 liter container) for 09A trans, G 055 025 A2 for

09G. Life-time filling, new fill quantity is for reference only. Only replace after repair (i.e. when removing oil pan). See Repair Manual (VESIS) for details.

DIFFERENTIAL AUTOMATIC TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 S2(1 liter container) . Life-time filling, new fill quantity is for

reference only. Only replace after repair. See Repair Manual (VESIS) for details.

COOLING SYSTEM: Use only phosphate-free coolant G 012 A8F A4, PURPLE COLORED. DO NOT INTERCHANGE OR MIX older G11(ZVW 237 105),GREEN

COLORED.This can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK COLORED. Frost protection is required down

to approximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately –35_C (–31_F). The anti-freeze ratio must

be a minimum of 40%, as otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates),

the amount of G 012 A8F A4 can be increased, but only up to 60%. This provides frost protection to approx. -40_C (–40_F). Do not reduce the coolant concentration

by adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced.

NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.